Информация о публикации

Просмотр записей

Инд. авторы:	Chirkov D.V., Shcherbakov P.K., Cherny S.G., Skorospelov V.A., Turuk P.A.
Заглавие:	Numerical investigation of the air injection effect on the cavitating flow in Francis hydro turbine
Библ. ссылка:	Chirkov D.V., Shcherbakov P.K., Cherny S.G., Skorospelov V.A., Turuk P.A. Numerical investigation of the air injection effect on the cavitating flow in Francis hydro turbine // Thermophysics and Aeromechanics. - 2017. - Vol.24. - Iss. 5. - P.691-703. - ISSN 0869-8643. - EISSN 1531-8699.
Внешние системы:	DOI: 10.1134/S0869864317050055; РИНЦ: 35523954; SCOPUS: 2-s2.0-85038882716; WoS: 000418306000005;
Реферат:	eng: At full and over load operating points, some Francis turbines experience strong self-excited pressure and power oscillations. These oscillations are occuring due to the hydrodynamic instability of the cavitating fluid flow. In many cases, the amplitude of such pulsations may be reduced substantially during the turbine operation by the air injection/ admission below the runner. Such an effect is investigated numerically in the present work. To this end, the hybrid one-three-dimensional model of the flow of the mixture “liquid−vapor” in the duct of a hydroelectric power station, which was proposed previously by the present authors, is augmented by the second gaseous component — the noncondensable air. The boundary conditions and the numerical method for solving the equations of the model are described. To check the accuracy of computing the interface “liquid−gas”, the numerical method was applied at first for solving the dam break problem. The algorithm was then used for modeling the flow in a hydraulic turbine with air injection below the runner. It is shown that with increasing flow rate of the injected air, the amplitude of pressure pulsations decreases. The mechanism of the flow structure alteration in the draft tube cone has been elucidated, which leads to flow stabilization at air injection. © 2017, Pleiades Publishing, Ltd.
Ключевые слова:	Three-dimensional model; Self excited oscillation; Numerical investigations; Hydroturbines; Hydroelectric power station; Hydrodynamic instabilities; Francis hydro-turbine; Air injection; Numerical models; Numerical methods; Hydroelectric power; Hydraulic turbines; Hydraulic motors; Flow of fluids; Cavitation; self-excited oscillations; numerical modeling; hydro turbines; cavitation; air injection; Hydroelectric power plants; Phase interfaces;
Издано:	2017
Физ. характеристика:	с.691-703
Цитирование:	1. F. Avellan, Introduction to cavitation in hydraulic machinery, in: The 6th Int. Conf. on Hydraulic Machinery and Hydrodynamics, Timisoara, Romania, 21−22 October 2004, P. 11-22. 2. O. Coutier-Delgosha, P. Morel, R. Fortes-Patella, and J.L. Reboud, Numerical simulation of turbopump inducer cavitating behavior, Int. J. Rotating Machinery, 2005, Vol. 2005, Iss. 2, P. 135-142. 3. S. Kurosawa, S.M. Lim, and Y. Enomoto, Virtual model test for a Francis turbine, in: IOP Conference Series: Earth and Environmental Sci. 2010, Vol. 12, No. 1, Proc. 25th IAHR Symp. on Hydraulic Machinery and Systems, P. 012063-1-012063-10. 4. L. Motycak, A. Skotak, and R. Kupcik, Kaplan turbine tip vortex cavitation-analysis and prevention, in: IOP Conference Series: Earth and Environmental Sci. 2012. Vol. 15, Part 3. Proc. 26th IAHR Symp. on Hydraulic Machinery and Systems, P. 032060-1-032060-8. 5. L.V. Panov, D.V. Chirkov, S.G. Cherny, I.M. Pylev, and A.A. Sotnikov, Numerical simulation of steady cavitating flows of viscous fluid in a Francis turbine, Thermophysics and Aeromechanics, 2012, Vol. 19, No. 3, P. 415-427. 6. D. Jošt and A. Lipej, Numerical prediction of non-cavitating and cavitating vortex rope in a Francis turbine draft tube, Strojniški vestnik - J. Mech. Engng, 2011, Vol. 57, No. 6, P. 445-456. 7. Y. Wu, S. Liu, H.-S. Dou, and L. Zhang, Simulations of unsteady cavitating turbulent flow in a Francis turbine using the RANS method and the improved mixture model of two-phase flows, Engng with Computers, 2011, Vol. 27, No. 3, P. 235-250. 8. V.Kh. Arm, V.M. Okulov, and I.M. Pylev, НInstability of the pressurized systems of hydraulic power-generating units, Izv. Ross. Akad. Nauk, Ser. Energetika, 1996, No. 3, P. 122-132. 9. V.B. Kurzin, Mechanism of the origin of low-frequency hydroacoustic auto-oscillations in the hydro aggregate flow duct, J. Appl. Mech. Tech. Phys., 2017 (in press). 10. V.V. Kasakevich, Auto-oscillations (Surge) in Compressors, Mashinostroenie, Moscow, 1974. 11. B.N. Yurkevich, Review of the paper by Lobanovskii Yu.I. “Auto-oscillations of pressurized systems and the rupture of hydro-aggregates”, Gidrotekhnicheskoe stroitelstvo, 2011, No. 1, P. 51-55. 12. J. Koutnik and L. Pulpitel, Modeling of the Francis turbine full-load surge, Modeling, Testing and Monitoring for Hydro Power plants, Lausanne, Switzerland, 1996, P. 143-154. 13. J. Koutnik, C. Nicolet, G.A. Schohl, and F. Avellan, Overload surge event in a pumped storage power plant, in: Proc. IAHR Symp. on Hydraulic Machinery and Systems, Yokohama, Japan, 2006, 14 p. 14. P. Dörfler, Evaluating 1D models for vortex-induced pulsation in Francis turbines, in: Proc. 3rd IAHR Working Group on Cavitation and Dynamic Problems in Hydraulic Machinery and Systems, Brno, Czech Republic, 2009, P. 315-324. 15. D. Chirkov, A. Avdyushenko, L. Panov, D. Bannikov, S. Cherny, V. Skorospelov, and I. Pylev, CFD simulation of pressure and discharge surge in Francis turbine at off-design conditions, in: Proc. 26th IAHR Symp. on Hydraulic Machinery and Systems, Beijing, China, 2012. 9 p. 16. D. Chirkov, L. Panov, S. Cherny, and I. Pylev, Numerical simulation of full load surge in Francis turbines based on three-dimensional cavitating flow model, in: Proc. 27th IAHR Symp. on Hydraulic Machinery and Systems, Montreal, Canada, 2014. 11 p. 17. D. Chirkov, S. Cherny, P. Scherbakov, and A. Zakharov, Evaluation of range of stable operation of hydraulic turbine based on 1D-3D model of full load pulsations, in: Proc. 6th IAHR Working Group on Cavitation and Dynamic Problems in Hydraulic Machinery and Systems, Ljubljana, Slovenia, 2015, P. 177-184. 18. B. Papillon, J. Kirejczyk, and M. Sabourin, Atmospheric air admission in hydro turbines, Hydrovision, 2000, Paper No. 3C. 19. P. Dörfler, M. Sick, and A. Coutu, Flow-Induced Pulsation and Vibration in Hydroelectric Machinery, Springer- Verlag, London, 2013. 20. V. Türkmenoglu, The vortex effect of Francis turbine in electric power generation, Turkish J. Electrical Engng and Computer Sci., 2013, Vol. 21, No. 1, P. 26-37. 21. C. Nicolet, Hydroacoustic modelling and numerical simulation of unsteady operation of hydroelectric systems, Ph. D. Thesis EPFL, 2007, No. 3751. 22. Y.S. Chen and S.W. Kim, Computation of turbulent flows using an extended k-ε turbulence closure model, NASA CR-179204, 1987. 23. P.J. Zwart, A.G. Gerber, and T.A. Belamri, Two-phase flow model for predicting cavitation dynamics, in: ICMF, 2004. Int. Conf. on Multiphase Flow, Yokohama, Japan. 2004, Paper No. 152. 24. S.G. Cherny, D.V. Chirkov, V.N. Lapin, V.A. Skorospelov, and S.V. Sharov, Numerical Simulation of Flows in Turbomachinery, Nauka, Novosibirsk, 2006. 25. R.F. Kunz, D.A. Boger, D.A. Stinebring et al., A preconditioned Navier−Stokes method for two-phase flows with application to cavitation prediction, Computers and Fluids, 2000, Vol. 29, No. 8, P. 849-875. 26. L.V. Panov, D.V. Chirkov, and S.G. Cherny, Numerical algorithm for modeling cavitational flow of a viscous fluid, Computational Technologies, 2011, Vol. 16, No. 4, P. 96-113. 27. S. Koshizuka and Y. Oka, Moving-particle semi-implicit method for fragmentation of incompressible, Fluid Nuclear Sci. Engng, 1996, Vol. 123, P. 421-434. 28. J. Martin and W. Moyce, An experimental study of the collapse of liquid columns on a rigid horizontal plane, Phil. Trans. Roy. Soc. London, Series A, Mathematical and Physical Sci., 1952, Vol. 244, No. 882, P. 312-324. 29. O. Ubbink, Numerucal prediction of two fluid systems with sharp interfaces. Ph. D. Thesis, Imperial College of Sci. Technology and Medicine, London, 1997. 30. R. Susan-Resiga, T.C. Vu, S. Muntean, G.D. Ciocan, and B. Nennemann, Jet control of the draft tube vortex rope in Francis turbines at partial discharge, in: IAHR Symp. on Hydraulic Machinery and Systems, Yokohama, Japan, 2006.